Kryptaglow® Automotive Glow Paint Part A (Solvent Base)

Material Safety Data Sheet

I. Identification
Manufactured By:		Kryptaglow™ P.O. Box 272672 Tampa, FL 33688 24 Hour Emergency Telephone CHEMTREC 1-800-424-9300	Revised: 06/11/06
Product Line:	Kryptaglow® Automotive Glow Paint Part A (Solvent Base)		Proper Shipping Name: Paint

II. hazardous ingredients
CAS #14808-60-7 Crystalline Silica ACGIH TLV: OSHA PEL: VAPOR PRESSURE:	ACGIH STEL: OSHA CEILING: LEL%:	WT%: 5-20 OSHA PEAK:	Footnote: (2)
CAS #110-43-0 Methyl Amyl Ketone ACGIH TLV: 50 PPM TWA OSHA PEL: 100 PPM TWA VAPOR PRESSURE: 2.14	ACGIH STEL: 75 PPM OSHA CEILING: LEL%: 1.1	WT%: 5-20 OSHA PEAK:	Footnote: (1)
CAS #123-86-4 Butyl Acetate ACGIH TLV: 150 PPM TWA OSHA PEL: 150 PPM TWA VAPOR PRESSURE: 7.8 mm Hg20C	ACGIH STEL: 200 PPM OSHA CEILING: LEL%: 1.7	WT%: 5-20 OSHA PEAK:	Footnote: (1)
CAS #64742-95-6 Aromatic 100 ACGIH TLV: OSHA PEL: VAPOR PRESSURE: 2.7mm Hg20C	ACGIH STEL: OSHA CEILING: LEL%: 0.9	WT%: 1-5 OSHA PEAK:	Footnote: (1)
WARNING MESSAGES: (1) Reports have associated repeated and prolonged occupational overexposure to solvents with permanent brain and nervous system damage. Intentional misuse by deliberately concentrating and inhaling the contents may be harmful or fatal. Chronic exposure may cause damage to the central nervous system, respiratory system, lung, eye, skin, liver, gastrointestional tract, spleen, kidneys, and blood. (2) IARC Monograph Volume 68, 1997 concludes that there is sufficient evidence that inhaled crystalline silica causes cancer in humans. IARC group 1. The NTP, in the Sixth Annual Report on Carcinogens, 1991, has added crystalline silica to its list of substances that are anticipated to be carcinogens (3) See Section IX for reportable Hazardous Air Pollutants

III. physical data

boiling range: 244-356º f

evaporation rate: * slower than ether *

PERCENT VOLATILE BY VOLUME: 40.42-45.55% WEIGHT PER GALLON: 9.24-11.37 Lbs.

VAPOR DENSITY: * heavier than air *

ACTUAL VOC (lb/gal): 2.83-3.17

EPA VOC (lb/gal): 2.84-3.18 EPA VOC (g/L): 340.35-381.09

IV. FIRE AND EXPLOSION HAZARD DATA

flash point: 90º F 32º C LEL: Refer to Section II

FLAMMABILITY CLASSIFCATION: Class 1C

DOT CLASSIFICATION (HAZARDOUS CLASS): * Flammable Liquid *

EXTINGUISHING MEDIA: * carbon dioxide, dry chemical, or fire foam *

Unusual fire and explosion hazards: With excessive heat, cans will rupture from internal pressure and discharge flammable contents. Vapors may ignite explosively. Keep away from heat, sparks and flame. Do not smoke. Extinguish all flames and pilot lights, and turn off stoves, heaters, electric motors and other sources of ignition during use and until all vapors are gone. Prevent build up of vapors by opening all windows and doors to achieve cross-ventilation.

SPECIAL FIRE FIGHTING PROCEDURES: Wear self-contained breathing apparatus and protective clothing. USE WATER WITH CAUTION. Material will float and may ignite on surface of water. Use water spray to keep fire exposed containers cool. Water may be ineffective in fighting the fire.

V. health hazard data

threshold limit value: See Section II

EFFECTS OF OVEREXPOSURE:

ACUTE: High vapor concentrations are irritating to the eyes and the respiratory tract, and may cause headaches, dizziness, anesthesia, drowsiness, unconsciousness, and other central nervous system effects, including death. Product has a low order of acute oral and dermal toxicity, but minute amounts aspirated into the lungs during ingestion or vomiting may cause mild to severe pulmonary injury and possibly death.

CHRONIC: This product contains crystalline silica which may cause delayed respiratory disease (silicosis) if inhaled over a long period of time. Avoid breathing dust. Use NIOSH/MSHA approved respirator when TLV for crystalline silica may be exceeded.

MEDICAL CONDITIONS PRONE TO AGGRAVATION BY EXPOSURE: Consult physician.

PRIMARY ROUTE(S) OF ENTRY: Skin and inhalation.

EMERGENCY AND FIRST AID PROCEDURES:

INHALATION: Remove to fresh air. Restore breathing. Treat symptomatically. Consult physician.

EYES: Flush immediately with large amounts of water for at least 15 minutes. Talk to a physician for medical treatment.

SKIN: Wipe off with towel. Wash with soap and water. Remove contaminated clothing.

INGESTION: If swallowed, call physician immediately. Remove stomach contents by gastric suction or induce vomiting only as directed by medical personnel. Never give anything by mouth to an unconscious person.

VI. reactivity data

stability: * stable * HAZARDOUS POLYMERIZATION: * will not occur *

INCOMPATIBLITY: Material can react violently with strong bases, strong oxidizing agents, and strong reducing agents.

HAZARDOUS DECOMPOSITION PRODUCTS: Fire, burning and welding may generate carbon monoxide.

CONDITIONS TO AVOID: Fire, burning, and welding.

VII. spill or leak procedures

steps to be taken in case material is released or spilled: Remove all sources of ignition (flames, hot surfaces and electrical, static or frictional sparks). Avoid breathing vapors. Ventilate area. Use non-sparking tools. Remove with inert absorbent.

WASTE DISPOSAL METHOD: Dispose of in accordance with local, state, and federal regulations.

VIII. special protection information

respiratory protection: In confined areas of poor ventilation, use chemical cartridge respirator or self-contained breathing apparatus.

VENTILATION: Provide general dilution or local exhaust ventilation in volume and pattern to keep TLV and LEL of most hazardous ingredient in Section II, below acceptable limit.

PROTECTIVE GLOVES: None required except for prolonged contact.

EYE PROTECTION: Splash proof eye goggles. In emergency situations, use eye goggles with a full face shield.

OTHER PROTECTIVE EQUIPMENT: * None *

HYGIENIC PRACTICES: See Section V

IX. special precautions

precautions to be taken in handling and storing: Do not store near heat, sparks or flame.

OTHER PRECAUTIONS: * None *

This product contains no reportable Hazardous Air Pollutants.

Co-Leash, Inc.

P.O. Box 272672

Tampa, FL 33688

(P) 813/920-1910 (F) 813/792-1418

www.kryptaglow.com